Tomas hated the sabatons.
He crossed the Blackworks yard in forty-three pieces of darkened steel and complained only of the two upon his feet. Plates slid at his shoulders and mail whispered beneath his arms. His round black shield rode upon his back; the sallet's open visor stood above a mail curtain and fitted gorget.
"They catch when I turn."
Noll knelt to feel the plate above his left toe. "Walk to the post and turn again."
Tomas obeyed, taking the corner more carefully. The steel caught once more.
Arthur circled him once. "Run."
Tomas ran.
The course took Tomas over the low wall and rail, between three close-set posts and up the tower stair beneath its low beam. He mounted from either side, dismounted into wet gravel, rolled and rose to cut at six hanging billets. Gawen struck from behind with a padded poleaxe. Tomas stumbled two paces, turned behind his shield and set his blunted sword against Gawen's throat.
"The stair and the roll once more," Jon called. "Slowly."
The right sabaton cleared both; the left caught on the stair and as Tomas rose. Noll had shortened both alike because the bare feet differed by less than a finger. Wool, hose and leather had made the difference worse.
Jon tapped the front of the boot. "Cut the left lames back. Give the toe more rise."
Noll chalked the new edge. Tomas lifted the foot to let him reach beneath it, then sat gratefully on the bench. Sweat had darkened every strip of linen visible beneath the plates.
Jon looked to the men waiting behind him. "Strip it. Jorren next."
The armourers had polished the steel to expose cracks, then darkened it with heat and oil until it shone like a rain-heavy sky. The plates moved over one another as a man bent, with mail closing the gaps. Jon wanted the household able to fight in a doorway or climb back into the saddle. Each fitting had to allow both.
Jorren needed more room at the chest; Rylas could not crouch behind his shield until Noll shortened the plates over his thighs. Olyver's shoulder locked above his head. Noll marked each fault and made the men repeat the movement that had found it.
"In most armouries, a common guard takes what fits least badly," Rodrik Cassel said.
He had come before breakfast and remained through the third fitting. His fingers kept returning to the sliding rivets of the shoulder piece Tomas had taken off.
"In most households, a common guard does not receive this much steel," Catelyn said.
She stood above the proof yard with Eddard, Robb, Luwin, Lady Dustin and Lords Manderly, Umber, Bolton and Cerwyn, who had come for the petitions after harvest. Theon sat on the gallery stair, his cup between his boots; Jory waited below. Catelyn's grey cloak was still clean from the road. Robb stood close beside her, auburn-haired and blue-eyed as his mother, though he was grinning at Tomas's complaints. Jon looked down at his own muddy boots.
Jon looked up at her. "They will be at my side in a breach. I want them properly armed."
Catelyn watched Noll ease Tomas back into the harness and loosen the shoulder straps. "Some of them had never owned a pair of boots when they came here."
"I remember."
Robb reached for a loose vambrace Noll had laid on the gallery ledge. Catelyn stopped him before he could fasten it. "You have your own armour. Leave the man his work."
She drew Robb a little nearer and asked whether his new cuffs had rubbed on the ride. Jon turned back to Noll. She had not asked after his. He knew better than to wait for it.
Jon pulled off his glove to help Noll with a fastening. The strap dragged across the red groove on his wrist. Mairi saw, took it from him and let it out a hole. "Wear it loose today, my lord. I shall move the strap when you have finished." He thanked her and bent to Noll's work.
At the rail the women disputed whose seam held best, loud enough for the watching lords to hear.
Eddard stepped down from the gallery to examine Tomas's harness. Catelyn stayed above with Robb until the covers came off the foot armour.
The retainers made a second audience along the rail. Wyman's man held his cloak; Smalljon had been left with Greatjon's. Catelyn and Barbrey leaned close to hear one another over the hammer.
Jon saw Eddard looking towards the tower above the works. Fresh mortar showed beneath the repaired battlements. A cart was climbing towards the granary, and on the cleared slope two plough teams moved in adjacent strips. His father had known the place when a man could shelter sheep in its hall. Jon waited until he looked back, then called Mairi to the covered racks.
The foot armour waited beneath sailcloth along the south wall. At Jon's signal, Mairi's women pulled the covers free.
Fifty sword-and-shield harnesses filled the first racks. Dark plates covered black quilted coats, with shorter pieces guarding arms and legs and mail at the throat. The open helms left the ears free to hear orders. Each round shield had an iron rim, a deep boss and straps that could be replaced upon the road.
The spear harnesses stood beside them, lighter about the arms so a man could level his spear or cast a pilum. Brimmed caps guarded the head; mail collars, breastplates and short steel skirts covered throat and body. Their long, curved shields stood ankle to shoulder, black-faced and bare of beasts. Spear, short sword and two weighted pila completed each man's issue.
Mairi pulled back the edge of a jack to show the padding that kept plate from chafing.
Greatjon Umber lifted one of the long shields, his enormous hand closing over its upper rim. "Too tall for running hills."
Hewyn stepped from the weapon rack. "You carry it higher when you run, my lord. Here, above the knee." He showed Greatjon the straps.
Greatjon put his arm through the straps and discovered the shield had been fitted for a smaller man. He ignored that, planted it, and demanded a spear. Hewyn gave him an ash stave with a padded head.
"Come, Smalljon."
His son grinned and took a second stave. Smalljon had his father's breadth coming into his shoulders, though he still had to look up to meet the older Umber's eye. They struck until the yard rail shook. The shield swallowed the first thrust, turned the second, and caught the third upon the rim. Greatjon attempted to rush. He brought the shield across to shove his son back, but its curved rim jammed against his own shoulder. Smalljon skipped clear before he could get the shield forward again.
Greatjon lowered the shield and rolled his shoulder. "I would not carry that on a hunt. Bring me five of your men; I want to see them use these together."
Hewyn called five spearmen from the waiting First Century. They came at a run, took shields from one rack and spears from another, and formed upon the painted line. One man wore boiled leather because his coat plates were still at proof. The other four carried steel upon head, throat, breast, and hip.
Greatjon walked around them. His amusement faded at the rear, where shield edges still overlapped and spear butts remained clear of one another. "Now move."
At Hewyn's nod the decanus gave the command. Five men crossed the packed earth together, opened at the ditch plank, closed beyond it, and turned with their shields facing the rail.
Greatjon followed them to the far end of the rail, watching their feet. One man shortened his stride over a rut; the others kept beside him.
The Umber laughed and handed back the practice spear. "I like them. Your flag is still ugly."
Jon smiled. "You are welcome to pay for the next one."
"Plain black. Did the painter charge by the beast?" Greatjon's broad face creased with amusement. He went to look at the helmets, still chuckling.
Roose Bolton had said nothing. He stood beside his thin master-at-arms, touching neither armour nor weapon. His pale grey gaze moved from fifty racks to six completed household harnesses, then to the hammer sounding below and the ore carts entering the gate.
"How many of these can you finish in a week?" Roose asked Noll, touching the edge of a foot breastplate.
Noll glanced at Jon before answering. "Twelve harnesses in a good week, my lord. Seven if too many pieces fail."
"Twelve?" Wyman looked along the racks again, his smile checked.
"The common issue," Noll said. "Not fitted household suits. We draw the rough plate in batches, then several benches work on it at once."
Wyman folded his great hands over a belly clothed in blue-green velvet, his pale blue eyes intent upon the hammer. "Even so. White Harbor could furnish ore, charcoal, hands, and a better road to the sea."
"Send the offer to my accountant, Abel," Jon said. "My men come first, but there will be bars and finished harness to sell once they are armed."
Roose asked whether his armourer might visit the lower furnace.
"He may inspect what we sell. The furnace work is closed."
Roose let his hand fall from the breastplate. He asked no more in front of the other lords.
Barbrey Dustin turned a brimmed cap to examine its lining. "The clocks bought this."
"The furnaces and the men to work them."
"I shall have to tell Willam what else his clock bought." She set the cap down and went to join Eddard.
Lord Cerwyn's master-at-arms asked to see the plate proof. Mikken wanted it as well. Noll led them behind the stone wing of the proof court.
In the proof court, Noll hung two breastplates over layered wool and packed clay. One had passed the armourers' trials. The other had been rejected because its lower edge showed a faint seam after raising. Both looked equally sound beneath oil.
Mikken took the measuring jaws. He checked the crown of the breast, the ribs, and the thinner metal at the belly. Noll showed him the same measurements on the pattern hung beside the rack. The greater thickness lay where the direct blows were expected; the turned edges and curve stiffened the rest.
"Choose the bow," Jon told Rodrik.
Rodrik selected Winterfell's heaviest crossbow from three upon the bench. Greatjon cocked it with a goat's-foot lever and asked for a quarrel with a narrow hard head. Noll paced out the shooting distance. Everyone withdrew behind the stone wing.
The bolt struck the accepted plate with a flat iron crack. The breast jumped upon its straps. Clay burst from the open neck. When Noll lifted it down, the quarrel hung bent beneath a deep bright dent. It had not passed through.
Noll worked the quarrel loose and gave it to Greatjon. The Umber held the bent point towards the light; its shaft had split at the head.
Wyman beckoned his armourer to the bench. Mikken felt around the back of the dent and the small raised tear where the steel had come closest to failing. Behind the outer rail men pressed forward until a Stark guard held the plate up for them. Several began speaking at once.
Roose stepped closer once the crossbow had been laid down. "The seam in the other one?"
Noll showed it to him, then hung the rejected plate back on the frame. The next quarrel entered beside the seam and tore through. When he lifted it down, Wyman put the sound plate beside it himself.
"The first would still hurt a man," Rodrik said. "Break ribs, perhaps stop his breath."
"Better than the quarrel through his chest." Jon pressed his fingers against the back of the dent.
Catelyn looked from the torn plate to the waiting soldiers. "And every one of them receives the first plate?"
"Steel from a tested charge," Jon said. "Then Noll checks each plate as it is shaped. That seam would have kept the second one off a man's back."
Catelyn touched the back of Robb's sleeve. "I would have Mikken inspect yours again before you hunt in it."
Robb was looking at the waiting shield line. "He can look at it tomorrow."
Fifty of Gerralt's sixty swordsmen took the yard after the proof. Martyn had armed them in stages so no man learned new weight upon the day of display. Their dark breastplates showed less steel than the household harness, but more than most northern levies saw outside a lord's retainers. Round shields locked across the lane. At Martyn's command the leading pair struck, covered, and passed rearward while the pair behind filled the place. No man swung wide enough to open his neighbour.
Robb leaned over the rail. "They look slower than your first boys."
"The armour is new to them."
"Those pieces below the knee too?"
"Aye. Watch how much the shield leaves uncovered when a man steps forward."
Martyn heard him. "Lord Robb, take an ash sword and find the knee."
Robb looked to Eddard, received a nod, and went down. Martyn gave him a practice helm and a shield. He fought one man, then two, then a closing four. Against one he touched the shoulder twice. Against two he reached a thigh and was struck across the helm. Against four, the line yielded, closed around his advance, and laid three padded blades upon him before he found a knee.
He returned red-faced and grinning. "I had the first one."
"And then the other three had you." Theon moved his cup to let Robb sit beside him on the stair.
Martyn stayed by the rail until the four had returned to their places. "I am having to unteach them things I spent years putting into boys," he said quietly to Jon. "Reach farther. Take the opening. Fine advice until it leaves the next man uncovered."
"They need that reach when they fight alone. Keep giving them their bouts."
"I do." Martyn glanced towards the four. "Will you let them face your household again? I have a few things for them to try."
"Ask Gawen for a day." Martyn beckoned the four forward again. This time he stood behind them, watching the men who waited to replace the leading pair.
Eddard watched the shields reset. "How many northern lords could put one hundred men in so much steel?"
Rodrik answered before Jon. "Few without stripping their knights, my lord. Fewer could replace it."
"The Manderlys," Wyman said pleasantly.
"And now he need not buy it from you," Barbrey said.
Jon looked beyond the rail. Only fifty shield harnesses stood ready. The other sword century was drilling at the Old Watch in its old leather and mail while Noll finished the plates. "I cannot arm both centuries in it yet."
Eddard turned to him. "But you will."
"Yes."
Roose looked from the ready harnesses to the empty racks. Catelyn kept her eyes upon Jon.
Medger drew Eddard a little aside while the men reset their shields. "I could call more men than this from my lands," he said. "Keeping them here through harvest, buying every coat and feeding them all winter—my steward would have something to say."
"So would mine," Greatjon said. "Loudly."
Medger watched a charcoal cart pass the gate. "The soldiers, these buildings, the horses. How much gold must those clocks bring him?"
"Enough to pay for what you see," Eddard said.
"And he is still taking orders," Wyman added.
"I saw the men waiting with purses," Barbrey said. "None looked likely to leave."
Roose stood beyond her, his hands hidden within his sleeves. "And when the rest of the armour is finished, the furnaces will remain."
Greatjon stopped testing the bent quarrel with his thumb and put it down.
Jon went to Noll for Tomas's measurements. Behind him Medger asked how soon he meant to fill the next barrack. His father turned and let Jon answer.
"With the next muster. The case makers have their benches; Woods can spare more men for the roof now."
Before the visitors left for the Old Watch, First Century's families gathered outside the armour room. Some had walked since dawn. A mother from the wolfswood rapped her son's steel cap with a knuckle. Two boys begged to lift a long shield and nearly fell beneath it together.
Mallador came from the armour room dressed as no one at his old holding had ever seen him. His jack was black wool over linen and tow. Steel covered crown, throat, breast, belly, and hip. The long shield rose from ankle to shoulder. A spear stood in one fist; two pila rested against the wall.
His elder brother stared longest at the boots. "They pay you to wear all that?"
"They pay me to carry it fifteen miles and dig before I take it off."
"You will drown in the first bog."
"Then you had better bring a rope." Mallador grinned and set the spear against the wall.
Their father did not laugh. He touched the breastplate, then removed his cap when he saw Jon beside the rack. "My lord, if he falls in your service…"
"His wages come to his family, and the death silver besides," Jon said. "We have the name he gave us in the wage book."
"Your name, Father," Mallador said. "I gave them yours."
The old man's fingers rested on the plate a moment longer before he let it go.
"Thank you, my lord." The man looked back at his son, still taking in the breadth of his shoulders. "He eats well here?"
"Ask him."
Mallador's brother pinched his upper arm. "He eats."
"Too much," their father decided, satisfied.
At the Old Watch, the banner rose at noon.
Finnan carried it from the tower gate. Once the narrowest of Tomas's boys, he had grown into his harness; only his face betrayed his youth. Blank black wool hung from the crossbar, its divided lower edge letting wind pass without wrapping it round the staff.
Tomas formed the household beneath it in four files, the first half of the intended fifty. Six wore fitted plate; the rest had their older mail beneath black mantles. Round uncharged shields covered their left sides, their swords riding high to clear the saddle. Lances stood behind. In a break of sun they looked closer to landed men-at-arms than the hungry children who had entered Jon's yard.
Arthur and Gawen mounted them. Tomas held command. Jon rode at the centre upon Bucephalus, in black wool and a lighter fitted breast because his body would outgrow expensive limbs within a season. The silver streak above his left temple showed beneath the edge of his open helm. He turned once to check the files behind him. The standard stood one horse behind his right shoulder.
They passed beneath the gate, wheeled upon the road, and returned at a canter. At the horn the outer files opened. Jon drove through the lane. They followed in two ranks, then closed behind him before the banner crossed the painted mark. A second horn broke the charge. Every horse returned to the starting line without a rider chasing applause.
A man beside the road took off his cap as they passed. His son rode in Gage's file, close enough for him to hear the stirrup leathers creak. He raised a hand; the young guard kept his shield up until Tomas called the halt.
Roose Bolton left before the second charge. His master-at-arms remained until the household dismounted and watched which men removed their own armour and how readily the younger men helped one another with the straps. Jon sent Gawen to escort him to the gate. Before dinner he told Abel to bring him any order from the Dreadfort before agreeing a price. He would sell Roose a clock readily enough. Steel was another matter; he knew whose men it might one day be used against.
Before the visitors rode back to Winterfell, servants brought bread and ale to the trestles beside the tower. Robb asked Jon for his chessboard and sent a boy inside to fetch it. Smalljon sat opposite him while Greatjon went on describing the breastplate proof to Rodrik.
"These all begin in the same places?" Smalljon asked.
"Every time." Robb put the last pawn in its rank and began showing him the moves. Smalljon reached for his queen as soon as he heard how far she could go; Robb made him look at the men standing in her way.
Wyman drew a chair nearer. He watched Robb move a knight over its own pawn, then asked to see it done again.
"Where did you find this game?"
"Jon devised it." Robb looked up at his brother and grinned. "He taught me."
Wyman turned the rough-cut knight between his fingers. "Will you have a set made for me? Wylis would enjoy this."
"Woods cut these," Jon said, sitting at the end of the trestle. "I shall ask for another set, with the rules."
"Let us finish the moves," Smalljon said. "Then Robb can try beating me." Robb grinned and turned the board to give him the pale men. Wyman stayed beside them, his cup clear of the pieces.
At Winterfell that evening, Jon stopped outside the family hall to unfasten his cloak. Catelyn was speaking beyond the partly open door.
"…you saw how those lords watched him, Ned. Only the gods know what some of them might be plotting…"
Her voice dropped. Jon slipped the clasp free and looked through the opening. She stood beside the hearth, facing Eddard, her brow drawn. He caught only a few more words.
"…but what if Robb…"
Robb and Theon came up behind him, still arguing over the afternoon's swordplay. Jon pushed the door open, but their voices covered Eddard's answer. His father shook his head once. He spoke briefly, with the same unyielding look Jon knew from a refused request. Catelyn's lips tightened. She said nothing more as Eddard turned to greet the boys.
Robb brushed past Jon, smiling as he called to their father. Jon followed him to the table.
Wylla made room for him beside Bran. The little boy had built a crooked rank of spoons across Jon's place and would not let anyone clear it until Jon had inspected the army.
"No horsemen?" Jon asked.
"Arya took the forks."
Across the table Arya hid her hands. Robb began to laugh. Catelyn called for the servants to bring the first dish, and the spoons went back to their places one by one. Bran surrendered the largest last, insisting that it was the captain. Jon put it beside his bowl.
Wylla set duck with onions and prunes before Jon, and he discovered how hungry he was. Eddard cut the pie while Robb leaned across Bran to describe Greatjon with the shield. It grew as he told it; by Smalljon's first thrust, Arya was standing to see over the table.
"Sit down," Catelyn said. "You may hear him from there."
"Did he fall?"
"No," Jon said, before Robb could improve upon it. "He asked to see the spearmen use it."
Theon held up a hand to show how much strap had remained beyond Greatjon's arm. "You should make one for him. Then no one else would steal it."
Sansa looked up from the pie. "Would it have his giant on it?"
"I expect so," Theon said.
"Your men ought to have something," she told Jon. "Even little silver stars would be pretty."
"They have cloaks for looking pretty." Robb reached for the mustard, still pleased with the men he had fought. "I want another turn against those four when we go back."
Eddard passed him the pot. "Then ask Martyn. He will be glad to keep you occupied."
Jon ate while the talk moved to the following day's hunt. Bran pushed the captain's spoon against his wrist and asked for more sauce. Across the candles, Catelyn cut the meat upon Arya's trencher. She had said little beyond calling for the dishes and correcting Arya. When Eddard turned to ask her something, she did not answer until he repeated her name. Then she set down the knife and looked up, her brow still drawn. Jon knew this table well enough to follow three conversations without joining any of them. He stayed until Bran grew heavy against his shoulder and Wylla came to take the little boy to bed. He had missed this sort of noise after his wife died. Then he had found the quiet tolerable, even useful, until a visit from the grandchildren reminded him what he had been tolerating. Bran's weight against his arm was welcome.
Wylla found him fetching his cloak and caught sight of the reddened skin above his glove. She brought out Lorren's salve. Jon sat while she worked it into the sore place at his wrist.
"Those lads' fathers could never have bought them what you showed us today," she said. "I saw how they looked at their sons outside the gate."
He smiled and gave her his other hand.
Wyman Manderly sent a new offer the following morning.
Greatjon sent six barrels of ale and a note demanding that the black shields learn to drink without breaking formation.
Jon returned to the Blackworks that morning to find Tomas waiting in the altered sabaton. The captain crossed the yard, turned sharply, climbed the stair and came down without catching either foot. At the bottom he drew his sword.
"That is better." He tried one last turn.
"Keep that cut with his pattern," Jon told Noll. "He will need another pair before we leave the North."
Outside, the plain black standard pulled once in the north wind and settled above the gate. Beneath it, First Century lifted its shields for the afternoon march.
* * *
Two mornings later Otho brought a wet rope and his figures to the schoolroom. He, Emrick and Henly had used the hammer's drive to raise a weighed load, measuring its height and timing the lift with a clock from the packing yard. Far less power reached the weight than the falling water should have given them.
Henly had found a pair of teeth binding. He shifted a wheel upon the drawing; Emrick objected that its shaft would block the passage for long iron, and they worked out a shorter one while Jon waited.
"Try the same lift after you change it," Jon told them. "Same water, same opening at the sluice."
Otho bent over the figures. "Still not enough for all the machines in dry weather. We might use the grinding stones while Ewan reheats his iron."
"Stand through a charge with him. Find out." Jon moved his chair as Lucan arrived for the soldiers' lessons. Henly and Emrick went out arguing about the bearings; Otho stayed to redraw the drive with fewer shafts.
* * *
In the last moon of the lease's second year, Woods brought the lifting frame from the final barrack roof to the eastern gate. Fourth's men took the ropes. Jon and Otho guided the beams into their seats between the towers, then stayed to fit the braces. By afternoon a fresh ten were bringing shingles past them, and a sentry could walk from the gate to the corner tower without descending to the yard.
Three mornings later Jon was riding out with Otho when his father's banner appeared. Robb and Theon came ahead, Eddard and Rodrik behind them, with Jory and the Stark guards following. Jon turned Bucephalus beneath the new gate roof to meet them.
"I could see the whole eastern side from the road," Eddard remarked as he came through.
"Nothing to hide behind at the ditch," Rodrik agreed, rain clinging to his white whiskers.
Jon led them down the main street between the six barrack ranges. A grain cart passed a century returning from drill; neither had to stop. Robb watched the last rank turn into its lane.
"That was why you left so much road. I thought you had wasted it when it was all string."
"And the kitchen is close," Theon added. "Robb should like that."
Beef and onions scented the air. Robb grinned and looked towards the cookhouse. Eddard was examining the empty ground behind the barracks.
"For the next sleeping bays," Jon explained. "There is room for the rest of the men without moving the bank."
They left their horses with Jory and went up the eastern corner tower. From there the ditch lay open along both sides, enclosing the straight streets and six barrack ranges. Beyond the bank were the hayfields, crofts and gardens.
Eddard said nothing for a while. His eyes followed the wallwalk to the gate roof they had ridden beneath, then returned to the old watchtower's crooked windows above the straight new roofs.
"Three hundred acres, a ruin and a road almost lost beneath the grass," he said. "I knew what you meant to build. It looks larger now that it stands."
Jon had spent two years going home with clay on his boots or shavings in his hair. The men who had hauled the timber now kept watch from it, with dry beds waiting below. He was looking towards the new gate roof when Eddard laid a hand upon his shoulder.
His father studied him in silence, then bent towards him and lowered his voice. "Where did you learn all this, Jon?"
Jon thought of the camp plans in the books he had owned, their gates and barrack rows marked in black. None of them stood on Luwin's shelves.
"Some of it from books," he said. "Hewyn told me where his old camps went wrong. I had room here to lay the roads out properly."
Eddard held his gaze a little longer. Then he took his hand away. "Show me the rest."
At Eddard's request Jon took them through the granary and down to the drain outfall. His father crouched beside the old flood stains. Rodrik lowered himself more stiffly to examine the fall. Jon showed them the drain's height above the stains and the openings left for clearing it.
"Have Otho bring his plan," Eddard said. "I want to see what lies beneath the roads."
Arthur met them at the tower stair. Upstairs Otho spread the drawing, and Eddard bent over it with Rodrik. Their questions kept Jon beside the trestle while Robb wandered to the window.
"Let me have a copy before you sail," Eddard said. "A new holding need not grow as Winterfell did. I should like to consider where else this arrangement would serve."
"Otho will make you one." Jon drew the edge of the sheet flat for him.
His father stayed over the drawing until Wylla leaned from her window and called that their dinner was getting cold. Robb was already on the stair. Theon followed, asking whether she had known they were coming. Eddard looked up at last, but left his gloves upon the plan. Jon fetched them for him on the way down.